DIY Home Improvement, Remodeling & Repair Forum > Appliances > Refrigerators > defrost problems





Reply
 
LinkBack Thread Tools Search this Thread Display Modes
Old 06-24-2012, 02:17 AM  
Tom-Fulcher
Junior Member
 
Join Date: Jun 2012
Posts: 2
Default defrost problems

Hi, We built a new house 5 years ago and furnished it with 10 new appliances, all GE Profile, based upon Consumer Reports high ratings. While the rest of our appliances have been great, we have had nothing but problems with our "French door" refrigerator. The problem is that the refrigerator portion will not keep it's cool. 

We have now learned that the "valve" between the bottom freezer and the fridge (that opens up to allow the cold air from the freezer to enter into the fridge) "frosts up" and will not open to allow the cold freezer air into the fridge. Therefore the fridge slowly warms up. 

it has taken us three repairmen visits to learn this (and considerable money) and finally the third repairman simply instructed us to shut off the power to the fridge, unload the contents of our fridge into our $100.00 old garage fridge (now 25 years old and working fine) and leave our fridge doors open. After about 12 hours, the ice on this valve melts; allowing the valve to operate normally at which time we then reload our fridge once again, eagerly anticipating the next failure. THIS IS A MONTHLY OCCURENCE FOR US!!!!!! We are extremely careful not to open the fridge or freezer for more than a few seconds at a time, as this seems to help delay the problem. Gone are the days of standing there with an open fridge door deciding on what's for supper. 

In fairness to GE, I contacted them the first time that I required a repairman to attend, and GE did step up to the plate and assist us financially with a portion of the repair bill. I think I dealt with "Cindy". She was actually real good to deal with. However, as the GE repairman is usually so booked up I have to wait days and days for him to attend. Therefore, the last time I used a local repairman, who was the one who informed me how to fix this problem without the need for another expensive service call (plus mileage). We live in the country, so getting a repair man out here is a big problem. 

If anyone reading this from GE wishes to comment on this issue, I'd be happy to hear from them. I can also be reached by anyone requiring more information at thefulchers@sasktel.net

Thanks



__________________
Tom-Fulcher is offline  
 
Reply With Quote Quick reply to this message
Old 06-25-2012, 10:47 AM  
woodchuck
Senior Member
 
Join Date: Jul 2008
Location: Tuscaloosa, Al
Posts: 236
Liked 14 Times on 13 Posts

Default

DEFROST PROBLEM
The evaporator coil behind the cover on the back wall inside the freezer will ice up under normal conditions. Every 8 to 10 hours for around 20 minutes the defrost timer (or in most newer models the electronic adaptive defrost control) will turn the defrost heater on to melt the built up ice. There is a defrost thermostat which prevents the heater from overheating the freezer by breaking the heater circuit when the temp reaches close to 32 degrees F. The entire cooling system shuts off during the defrost cycle and starts back when the timer advances through the cycle.

If this ice is not melted it will continue to build up until the air can’t flow over the coil to circulate the cold air through the freezer and into the fridge. The temperature change in the fridge is usually noticed first followed by the freezer.

If the defrost thermostat is bad, it can prevent the heater from coming on OR it won’t turn the heater off when it gets too warm. It is clamped to the evaporator coil at the top to sense the temp. If it appears to be misshapen it is bad.
With an ohm meter it should show continuity when cold and none when warm.
You can also bypass(disconnect the two wires plugged into it and twist them together) the thermostat to see if the heater comes on then. If it does then you know the thermostat is bad and needs replaced.

The defrost heater is located on the evaporator. It is in a tube which is at the bottom and can also go up the sides of the evaporator. On some types you can see a burnt spot if it’s bad. With an ohm meter it should show continuity from end to end when disconnected from the wiring in the freezer. You can also test the wiring for voltage when it’s in the defrost mode.

If you have a defrost timer you can test it. It can be located under the fridge behind the kick panel on the front. Some are in the fridge with the controls at the top. You can turn the defrost timer till it clicks and everything shuts down. The heater should now come on. If it does, replace the timer because that means the timer is not running. If it doesn't, check the heater and defrost thermostat. Turn the timer again till everything starts back up to end the defrost cycle.

If you have an adaptive defrost control instead of a timer, replace it if the heater and thermostat test good. It is located in the fridge with the controls in some models and on the back in others. You can post your model number into one of several appliance parts sites on the internet and search for defrost components to find your parts.



__________________
woodchuck is offline  
 
Reply With Quote Quick reply to this message
Old 06-25-2012, 02:16 PM  
jeff1
Senior Member
 
jeff1's Avatar
 
Join Date: Mar 2006
Posts: 411
Liked 17 Times on 16 Posts
Likes Given: 1

Default

Quote:
we have had nothing but problems with our "French door" refrigerator.
Model#?
A lot ( most? ) of these are not GE and are built by someone else for GE.

http://www.applianceaid.com/model-number.php Some model# helps.

jeff.
__________________

Appliance Repair Aid
http://www.applianceaid.com/
I support MADD, please don't drink and drive!

jeff1 is offline  
 
Reply With Quote Quick reply to this message
Old 06-25-2012, 09:35 PM  
Tom-Fulcher
Junior Member
 
Join Date: Jun 2012
Posts: 2
Default

Woodchuck, thank you for your detailed reply. I even understood most of it ... lol. When I get some time, I will try the steps you so kindly suggested. Thanks again.

Tom

__________________
Tom-Fulcher is offline  
 
Reply With Quote Quick reply to this message
Reply


Quick Reply
Message:
Options

Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter DIY Home Repair Forum Replies Last Post
Magic Chef defrost timer stops MCBR1010W robert96822 Refrigerators 9 11-04-2012 08:14 PM
defrost timer Bob Krueger Refrigerators 1 08-11-2011 12:53 PM
Magic Chef RB19KN-4A/AG64A Defrost Heater srt842 Refrigerators 3 09-01-2009 09:11 AM
Where is the defrost timer!? Please Help ved1975 General Appliance Discussion 1 04-27-2009 10:07 PM