DIY Home Improvement, Remodeling & Repair Forum

DIY Home Improvement, Remodeling & Repair Forum (http://www.houserepairtalk.com/forum.php)
-   Refrigerators (http://www.houserepairtalk.com/f113/)
-   -   Haier refrigerator freezing while freezeer is not (http://www.houserepairtalk.com/f113/haier-refrigerator-freezing-while-freezeer-not-10950/)

TroyC 03-15-2011 03:31 AM

Haier refrigerator freezing while freezeer is not
 
I have a Haier refrigerator with a top freezer. The freezer part is just barely below 32 degrees, not cold enough to freeze food solid. When we turn down controller in fridge (there isn't a controller in freezer) the fridge part starts to freeze food while freezer part doesn't get that much colder.

What do you suspect is the problem?

Thanks.

kok328 03-15-2011 10:39 AM

One problem could be the frost free defroster is stuck in the on position. Another problem could be something is blocking the air vent between the fridge and freezer sections.

nealtw 03-15-2011 06:44 PM

The defrost heater is not working.

TroyC 03-15-2011 11:22 PM

What can I do or how can I fix either of these problems? Something I can do myself or do I need an expert?

nealtw 03-16-2011 08:52 PM

I would call a pro.

woodchuck 03-17-2011 01:37 PM

It may be simple. It's worth looking at this-

The evaporator coil behind the cover on the back wall inside the freezer will ice up under normal conditions. Every 8 to 10 hours for around 20 minutes the defrost timer (or in most newer models the electronic adaptive defrost control) will turn the defrost heater on to melt the built up ice. There is a defrost thermostat which prevents the heater from overheating the freezer by breaking the heater circuit when the temp reaches close to 32 degrees F. The entire cooling system shuts off during the defrost cycle and starts back when the timer advances through the cycle.

If this ice is not melted it will continue to build up until the air canít flow over the coil to circulate the cold air through the freezer and into the fridge. The temperature change in the fridge is usually noticed first followed by the freezer.

If the defrost thermostat is bad, it can prevent the heater from coming on OR it wonít turn the heater off when it gets too warm. It is clamped to the evaporator coil at the top to sense the temp. If it appears to be misshapen it is bad.
With an ohm meter it should show continuity when cold and none when warm.
You can also bypass(disconnect the two wires plugged into it and twist them together) the thermostat to see if the heater comes on then. If it does then you know the thermostat is bad and needs replaced.

The defrost heater is located on the evaporator. It is in a tube which is at the bottom and can also go up the sides of the evaporator. On some types you can see a burnt spot if itís bad. With an ohm meter it should show continuity from end to end when disconnected from the wiring in the freezer. You can also test the wiring for voltage when itís in the defrost mode.

If you have a defrost timer you can test it. It can be located under the fridge behind the kick panel on the front. Some are in the fridge with the controls at the top. You can turn the defrost timer till it clicks and everything shuts down. The heater should now come on. If it does, replace the timer because that means the timer is not running. If it doesn't, check the heater and defrost thermostat. Turn the timer again till everything starts back up to end the defrost cycle.

If you have an adaptive defrost control instead of a timer, replace it if the heater and thermostat test good. It is located in the fridge with the controls in some models and on the back in others.


All times are GMT -6. The time now is 05:59 AM.