DIY Home Improvement, Remodeling & Repair Forum > Appliances > Refrigerators > Maytag cooling intermitantly





Reply
 
LinkBack Thread Tools Search this Thread Display Modes
Old 08-03-2011, 05:46 AM  
BRIANL00
Junior Member
 
Join Date: Oct 2010
Location: INDIANAPOLIS, IN
Posts: 21
Default Maytag cooling intermitantly

I have a Maytag self defrosting refrigerator(Bottom Freezer, Top Refrigerator). A while ago the refrigerator stopped cooling. I adjusted the temperature setting to the coldest setting and it still did not cool. I noticed the vents on the back wall in the freezer were frosted up so I unplugged the unit and let it defrost for a whole day. When I plugged the unit back in, the next day, the refrigerator started working again. Then, about two weeks later, the refrigerator stopped cooling again. All the time I have had this problem, both the freezer and the ice maker have worked fine.



__________________
BRIANL00 is offline  
 
Reply With Quote Quick reply to this message
Old 08-03-2011, 10:54 AM  
woodchuck
Senior Member
 
Join Date: Jul 2008
Location: Tuscaloosa, Al
Posts: 238
Liked 15 Times on 14 Posts

Default

DEFROST PROBLEM
The evaporator coil behind the cover on the back wall inside the freezer will ice up under normal conditions. Every 8 to 10 hours for around 20 minutes the defrost timer (or in most newer models the electronic adaptive defrost control) will turn the defrost heater on to melt the built up ice. There is a defrost thermostat which prevents the heater from overheating the freezer by breaking the heater circuit when the temp reaches close to 32 degrees F. The entire cooling system shuts off during the defrost cycle and starts back when the timer advances through the cycle.

If this ice is not melted it will continue to build up until the air can’t flow over the coil to circulate the cold air through the freezer and into the fridge. The temperature change in the fridge is usually noticed first followed by the freezer.

If the defrost thermostat is bad, it can prevent the heater from coming on OR it won’t turn the heater off when it gets too warm. It is clamped to the evaporator coil at the top to sense the temp. If it appears to be misshapen it is bad.
With an ohm meter it should show continuity when cold and none when warm.
You can also bypass(disconnect the two wires plugged into it and twist them together) the thermostat to see if the heater comes on then. If it does then you know the thermostat is bad and needs replaced.

The defrost heater is located on the evaporator. It is in a tube which is at the bottom and can also go up the sides of the evaporator. On some types you can see a burnt spot if it’s bad. With an ohm meter it should show continuity from end to end when disconnected from the wiring in the freezer. You can also test the wiring for voltage when it’s in the defrost mode.

If you have a defrost timer you can test it. It can be located under the fridge behind the kick panel on the front. Some are in the fridge with the controls at the top. You can turn the defrost timer till it clicks and everything shuts down. The heater should now come on. If it does, replace the timer because that means the timer is not running. If it doesn't, check the heater and defrost thermostat. Turn the timer again till everything starts back up to end the defrost cycle.

If you have an adaptive defrost control instead of a timer, replace it if the heater and thermostat test good. It is located in the fridge with the controls in some models and on the back in others.



__________________
woodchuck is offline  
 
Reply With Quote Quick reply to this message
Old 08-04-2011, 05:12 AM  
BRIANL00
Junior Member
 
Join Date: Oct 2010
Location: INDIANAPOLIS, IN
Posts: 21
Default Re:defrost problem

Thanks for the info woodchuck! I will look into it.

__________________
BRIANL00 is offline  
 
Reply With Quote Quick reply to this message
Old 08-09-2011, 07:07 AM  
BRIANL00
Junior Member
 
Join Date: Oct 2010
Location: INDIANAPOLIS, IN
Posts: 21
Default Re:defrost problem

woodchuck:

I think my defrost thermostat is bad because it is misshapen, and also, when I bypassed it and connected the two wires plugged into it the defrost heater came on.
I have a follow-on question about the defrost timer. Once I install the new defrost thermostat, may I wind the defrost timer to just before it clicks, plug in the refrigerator and see if the timer advances to the click and shuts everything down to see if the timer is working?

__________________
BRIANL00 is offline  
 
Reply With Quote Quick reply to this message
Old 08-09-2011, 08:15 AM  
woodchuck
Senior Member
 
Join Date: Jul 2008
Location: Tuscaloosa, Al
Posts: 238
Liked 15 Times on 14 Posts

Default

Yes, you can put the timer anywhere you want to and once you see if it advances and shuts down and the heater comes on you can turn it to end the defrost cycle if it doesn't need to defrost.(no ice on coils) although the compressor won't come back on till the pressure has equalized in the system.(a few minutes).

__________________
woodchuck is offline  
 
Reply With Quote Quick reply to this message
Old 08-10-2011, 06:24 AM  
BRIANL00
Junior Member
 
Join Date: Oct 2010
Location: INDIANAPOLIS, IN
Posts: 21
Default

I think I'm back in business. I installed a new defrost thermostat yesterday. I also tested the defrost timer. I put everything back together and plugged it in yesterday and this morning the freezer is @ 0 degrees F. and the refrigerator is @ 39 degrees F. and I have ice! Thanks.



__________________
BRIANL00 is offline  
 
Reply With Quote Quick reply to this message
Reply


Quick Reply
Message:
Options

Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter DIY Home Repair Forum Replies Last Post
Maytag dishwasher door won't lock Fred5977 General Appliance Discussion 1 01-14-2011 05:18 PM
Maytag Model# LDE7600ACL loud clicking noise ghh3rd General Appliance Discussion 2 08-27-2010 12:13 PM
door would not close/lock on Maytag dishwasher ilyaz General Appliance Discussion 1 04-21-2010 07:06 PM
Maytag dishwasher - l997 Help Me! Introductions 0 08-18-2009 05:47 PM
Maytag front load washer crazy shaking hgiljr General Appliance Discussion 1 07-21-2009 07:04 AM