DIY Home Improvement, Remodeling & Repair Forum > General Discussion > Introductions > Water in Duct in Mobile Home





Reply
 
LinkBack Thread Tools Search this Thread Display Modes
Old 06-04-2008, 10:47 PM  
Blondee
Junior Member
 
Join Date: Jun 2008
Posts: 2
Default Water in Duct in Mobile Home

I hope some one can give me some information on this topic. I live in a mobile home. A little more than a year ago, I had to get a new furnace. Installation went with out a hitch. My trailer is 30 years old, and was lucky to find a furnace that would fit the spot. At the end of last summer I found about three inches of water in the one duct that runs almost the full length of the trailer. I cyphoned the water out and by the time the heat had to go on, the duct was dry.
Promising myself to deal with it before a catastrophe occurs, I have had 2 people check out the duct, trying to find why the water would collect in the duct. I have had the duct cleaned and it wasnt very dirty to my surprise. But after running the air conditioner for a few hours, there was about 1/2 inch of water in the duct in the area just the other side of where the furnace is located. The entire duct was NOT filled with any water at all. I was told the drip pan located under the furnace was dry.
Its hard to find people to work on trailers, so I am at a disadvantage.
What I need to relay to the person who is helping me is what can possibly be blocking the drainage of the water, and what can we do about it? I love my trailer, but it really heats up in here in the summer, so I really need some help here ASAP and would greatly appreciate any light any one can shine on this situation.
Please & Thanks,
Blondee



__________________
Blondee is offline  
 
Reply With Quote Quick reply to this message
Old 06-05-2008, 12:16 PM  
hondadrv24
Senior Member
 
Join Date: Feb 2008
Posts: 188
Liked 1 Times on 1 Posts

Default

Greetings blondee,

sounds to me like the drainage of your condenser is not working properly, Can't remember from my trailer days how it drained, but in a house we usually have a flexable tubing approximately 3/4" in diameter that goes from the condenser that is located on the duct side trunking of the furnace which drains the water from the condenser away to a drain, (possibly just under the trailer in your situation).

I'm wondering if the person who installed the new furnace somehow either did not put the tubing back in place. Or maybe the tubing has a crack or is plugged causing the water to drain into your ductwork.



__________________
hondadrv24 is offline  
 
Reply With Quote Quick reply to this message
Old 06-07-2008, 03:34 PM  
kok328
Supporting Member
 
Join Date: Nov 2007
Location: Grand Blanc, MI
Posts: 2,081
Liked 71 Times on 66 Posts
Likes Given: 50

Default

There is no water and/or drainage in/on/around or otherwise by the condensor coils.
To solve this problem, you will need to channel the condensation coming from the evaporator coils to the outside.

__________________
kok328 is offline  
 
Reply With Quote Quick reply to this message
Old 06-07-2008, 06:30 PM  
glennjanie
Senior Member
 
Join Date: Mar 2006
Posts: 2,992
Liked 2 Times on 2 Posts

Send a message via AIM to glennjanie
Default

Welcome Blondee:
Looking at the furnace, you will notice it is sitting on top of an extra box. The box should have a copper line the size of your pinky finger running into it and another copper line larger than your thumb coming out. When the air conditioner is running the small line will be slightly warm and the larger one will be somewhat cool, maybe even frosty.
Below the two copper lines there should be another line comming out of the box that is still larger and made of white plastic. That is the drain line for the condensate (water) that comes off the evaporator coils and should run to the outside, down near the ground and have a trap in the end of it to keep the bugs out.
If yours has a white plastic plug screwed into the box, your installer forgot to drain it and the water spills out into your ductwork. In that case you should call the installer back and ask them to complete the drain.
Glenn

__________________
glennjanie is offline  
 
Reply With Quote Quick reply to this message
Old 06-07-2008, 08:07 PM  
hondadrv24
Senior Member
 
Join Date: Feb 2008
Posts: 188
Liked 1 Times on 1 Posts

Default

Actually Glenn, I think (if i remember correctly) that the condenser is on the bottom side since the ducts run under the house.

__________________
hondadrv24 is offline  
 
Reply With Quote Quick reply to this message
Old 06-08-2008, 09:18 AM  
kok328
Supporting Member
 
Join Date: Nov 2007
Location: Grand Blanc, MI
Posts: 2,081
Liked 71 Times on 66 Posts
Likes Given: 50

Default

hondadrv24, the condensor coils will be outside with the compressor. You are consistently getting your coils confused.
Glennjanie, any chance that the condesated line could be copper or poly? Any chance that the pvc tube could be other than white?
Blondee, if the condensate line is missing, have one installed. If the condensate line is present, check it to see if it is plugged.

Yea, I woke up on the wrong side of the bed again

__________________
kok328 is offline  
 
Reply With Quote Quick reply to this message
Old 06-08-2008, 09:48 AM  
hondadrv24
Senior Member
 
Join Date: Feb 2008
Posts: 188
Liked 1 Times on 1 Posts

Default

You're right, I meant the evaporator coils.

__________________
hondadrv24 is offline  
 
Reply With Quote Quick reply to this message
Old 06-08-2008, 03:38 PM  
Blondee
Junior Member
 
Join Date: Jun 2008
Posts: 2
Default Many Thanks!


Many thanks for the information gathered here in easy to understand language. I will print out this info and pass it along to the guy who will be coming to look at it this week.
Thanks for sharing your knowledge. I would not hesitate to use this site again for other topics.
Blondee


__________________
Blondee is offline  
 
Reply With Quote Quick reply to this message
Reply


Quick Reply
Message:
Options

Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter DIY Home Repair Forum Replies Last Post
What is the best Water Proof Duct Tape? artnews300 Windows and Doors 2 02-08-2008 06:49 AM
Article - Home Security Systems: What to Choose "L" General Home Improvement Discussion 0 01-29-2007 01:26 PM
Home Security TxBuilder General Home Improvement Discussion 1 10-11-2006 01:30 AM
Please Help Diagnose Leaking Mobile Home (New) Includes Pics Vik61 Roofing and Siding 18 09-21-2006 06:44 AM