DIY Home Improvement, Remodeling & Repair Forum > DIY Home Improvement > Flooring > Removing Vinyl and Underlay from around cabinets




Reply
 
Thread Tools Search this Thread Display Modes
Old 11-19-2011, 07:12 PM  
neefg
Junior Member
registry_dropdown_24671_64041
 
Join Date: Nov 2011
Posts: 4
Default Removing Vinyl and Underlay from around cabinets

I need to replace the glued down sheet vinyl in my kitchen but the cabinets are installed on top of it. Ideally I would like to remove the old vinyl and 1/4' underlayment completely and install tile without having the wasted additional height. However, taking out the cabinets seems rather problematic given the countertop back splash being attached to the wall. I can't think of any good way to cut out around the cabinets to get the old stuff out. Is there a tool that will cut cleanly, closely and and at the right depth, under a cabinet toe kick so i could get that stuff out?


neefg is offline  
 
Reply With Quote
Old 11-19-2011, 07:23 PM  
joecaption
Senior Member
registry_dropdown_21184_64042
 
Join Date: Jan 2011
Location: Hartfield VA, VA
Posts: 1,472
Liked 74 Times on 61 Posts
Likes Given: 2

Default

Sure is, it's called a Toe Kick Saw.
3-3/8" Blade Toe-Kick Saw
Crain makes a better one but if your only doing this one job I'd get this one. Home Depot also rents one. A new Crain is a couple of hundred bucks.
It will cut right to a wall or under a toe kick and not mark it up.
I'd use an Ossilating saw to make the final cuts in the corners where the toe kick can not reach.
A Toe kick uses 2, differant sized blades, one cuts 3/4 deep the other cuts 3/8". The depth is not adjustable. You could lay a piece of 1/4" plywood down under it to lift it up some.
I'd cut that floor in sections with a ciruler saw set to just a little more then 1/4" deep to make it easyer to rip out.


joecaption is offline  
 
Reply With Quote
Old 11-21-2011, 04:57 AM  
neefg
Junior Member
registry_dropdown_24671_64089
 
Join Date: Nov 2011
Posts: 4
Default

thanks. never heard of that before. I'll. check it out
neefg is offline  
 
Reply With Quote
Old 11-21-2011, 10:25 AM  
samfloor
Carpet Installer
 
samfloor's Avatar
registry_dropdown_18647_64099
 
Join Date: May 2010
Location: Buckner, Missouri
Posts: 225
Liked 24 Times on 20 Posts
Likes Given: 5

Default

Be careful. That saw can kick back and it's very easy to get hurt using it. But it is the best option.
__________________
[url]http://www.flooringforum.com/forum/[/url]


(AKA Floorist, Rusty Baker)
samfloor is offline  
 
Reply With Quote
Old 11-21-2011, 11:00 AM  
nealtw
Contractor
registry_dropdown_20526_64104
 
Join Date: Nov 2010
Location: Upper Fraser Valley, British Columbia
Posts: 12,929
Liked 1273 Times on 1121 Posts
Likes Given: 2138

Default

Make sure the old underlayment wasn't glued down.
nealtw is offline  
 
Reply With Quote
Old 11-21-2011, 04:20 PM  
isola96
Senior Member
 
isola96's Avatar
registry_dropdown_24199_64126
 
Join Date: Oct 2011
Location: Lagrangeville, New York
Posts: 437
Liked 7 Times on 7 Posts

Default

Many people even carpenters have never heard of toe kick saw it's a wonder full tool and when using it for light cut won't kick around on you if you take your time.
This old house uses it religiously.
isola96 is offline  
 
Reply With Quote
Old 11-27-2011, 06:00 AM  
joecaption
Senior Member
registry_dropdown_21184_64365
 
Join Date: Jan 2011
Location: Hartfield VA, VA
Posts: 1,472
Liked 74 Times on 61 Posts
Likes Given: 2

Default

I've used mine to cut out water damaged area under kitchen sinks, and it even cut the subflooring below it that was also rotted.
Most old houses for some reason installed the base boards then installed the hardwood flooring, so the nails holding the base board are below the flooring.
I just turn the toe kick on end and cut the base board to the corners and finish with an ossilating saw.
I also have a diamond blade for it to cut tile floors when the cabinets are sitting on top of the old tile.
What other saw can cut out in front of a tub and leave no gap with no damage to the tub or under kitchen cabinets toe kicks without scratching the toe kick.
Try that with a sawsall.
joecaption is offline  
 
Reply With Quote
Old 11-30-2011, 08:07 AM  
neefg
Junior Member
registry_dropdown_24671_64536
 
Join Date: Nov 2011
Posts: 4
Default

I gave the Chicago brand multi-tool a try. It will cut through the underlayment, however, the clearance under the toe-kick is not good and the depth of cut is a bit arbitrary. It turns out cutting it is the least of my problems. 10p ring shank nails every 6 inches pretty well preclude my pulling up the old underlayment. I am currently using the l scrapper attachment on the multi-tool to remove the old vinyl. at this point i don't see an option other than getting the old vinyl up and then level the floor and laying more vinyl.

Last edited by neefg; 11-30-2011 at 08:09 AM.
neefg is offline  
 
Reply With Quote
Old 11-30-2011, 08:37 PM  
joecaption
Senior Member
registry_dropdown_21184_64552
 
Join Date: Jan 2011
Location: Hartfield VA, VA
Posts: 1,472
Liked 74 Times on 61 Posts
Likes Given: 2

Default

1/4" under layment is not an excepted subfloor for tile, so it needs to come out.
Sorry.
http://www.creativeceramicandmarble.com/floors.htm



Last edited by joecaption; 11-30-2011 at 08:50 PM.
joecaption is offline  
 
Reply With Quote
Reply


Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


Similar Threads
Thread Thread Starter DIY Home Repair Forum Replies Last Post
Removing built-in wall cabinets? HomeRepairMike General Home Improvement Discussion 2 05-10-2011 10:48 AM
removing and replacing vinyl siding sisyphus General Home Improvement Discussion 4 04-05-2011 05:17 PM
Removing kitchen cabinets with no back panels Christian General Home Improvement Discussion 3 09-15-2010 05:02 AM
Removing vinyl sheet flooring WestBentley Flooring 6 03-30-2007 06:17 PM
Kitchen vinyl under cabinets audaceblue Flooring 2 06-27-2006 01:56 AM

Newest Threads

LATEST SPONSOR DEALS