DIY Home Improvement, Remodeling & Repair Forum > DIY Home Improvement > Bricks, Masonry and Concrete > Building barn walls out of cinder block.




Reply
 
Thread Tools Search this Thread Display Modes
Old 01-23-2009, 09:38 PM  
tybgee
Junior Member
 
Join Date: Jan 2009
Posts: 2
Default Building barn walls out of cinder block.


My husband and I are purchasing a home with several acres to build a horse farm. The house is great but we will be building barns from the ground up. A poured cement aisle, and stall floors that are layered gravel topped with lime and then rubber mats, are a few things decided. When looking at several options for the barn stall walls I am pretty well decided on using cinder block for many reasons: strength to stand up to horses, insulation built in, and relatively cheap to buy. My husband is headed to Iraq, and most of my family is a good 3 hours away so I would be trying to do most of the work by myself, but I would like to put the walls up myself. My dad doesn't think it is something I should even attempt but I see big $$$ in paying somebody else. I guess my questions would be
1. is it really that hard, or would I be able to manage it after plenty of research and some practice?
2. if possible any advice on the best way to start and finish and everything in between
Also open to other suggestions for any of the barn if you have any!!
Laura


In doing some extra research I found a page about surface bonding cement (SBC) is this anything that you may have heard of? Does it really work as well as they say?

http://www.thenaturalhome.com/drystackblock.htm

That is the site I was reading it on.


__________________

Last edited by tybgee; 01-24-2009 at 04:53 PM. Reason: Found new research.
tybgee is offline  
 
Reply With Quote Quick reply to this message
Old 01-24-2009, 12:47 PM  
storage_man
Junior Member
 
Join Date: Jan 2009
Posts: 13
Default

Laura

First off, I'm a DIY'er and have laid my share of cinder block and red brick. I would bet after your first course, you would probably not be able to stand upright for days. The pain would be immense. I know I have done it. Laying cinder block walls is very strenuous and the higher you get the worse it gets.
I would recommend that you find a qualified professonal for that job.

Now as for build a barn out of cinder block, it has many benefits, as well as a couple of issues. Cinder block is pretty rough and I would be concerned with your animals injuring themselves on the rough surfaces. Next is hanging things. There are alot of options for hanging items on a cinder block wall. The downside is that extremely heavy items need to be thru bolted with steel plates for reinforcement. My wife had a horse and I remember all of the tack and other stuff hung on the walls of the barn.

Hope this gives you some ideas.



__________________
storage_man is offline  
 
Reply With Quote Quick reply to this message
Old 01-24-2009, 02:30 PM  
tybgee
Junior Member
 
Join Date: Jan 2009
Posts: 2
Default

Quote:
Originally Posted by storage_man View Post
Laura

First off, I'm a DIY'er and have laid my share of cinder block and red brick. I would bet after your first course, you would probably not be able to stand upright for days. The pain would be immense. I know I have done it. Laying cinder block walls is very strenuous and the higher you get the worse it gets.
I would recommend that you find a qualified professonal for that job.

Now as for build a barn out of cinder block, it has many benefits, as well as a couple of issues. Cinder block is pretty rough and I would be concerned with your animals injuring themselves on the rough surfaces. Next is hanging things. There are alot of options for hanging items on a cinder block wall. The downside is that extremely heavy items need to be thru bolted with steel plates for reinforcement. My wife had a horse and I remember all of the tack and other stuff hung on the walls of the barn.

Hope this gives you some ideas.
As far as the physical work, I know it will be tough, but just getting off Active Duty Army I am up for that. As far as a tack room the plan is to build that as a seperate part with temperature control and security since this will all be part of a business. Thanks for the info!
__________________

Last edited by tybgee; 01-24-2009 at 04:51 PM.
tybgee is offline  
 
Reply With Quote Quick reply to this message
Old 01-24-2009, 06:12 PM  
inspectorD
Housebroken
HRT_MODERATOR.png
 
inspectorD's Avatar
 
Join Date: Dec 2005
Location: Litchfield, CT
Posts: 4,093
Liked 125 Times on 105 Posts
Likes Given: 319

Default well

If I was going to build a DIY barn for a relatively low cost, I would do a pole barn. They are easy to build, and with a truss system they are fast to go up.
If you start out with some concrete piers and brackets, it will be easier to build as a system. You can build a couple of "bents" like a barn has right on the ground . Then hire a crane to lift them into place. They hire out for about 4oo a day, A Friend of mine does this for a living.
Then get your braces up and your 2x12 beams up , bolted to each bent. Then hire the crane back for another day for trusses.
This is the easiest and least expensive route to go. Just check out any fairground building and you will get the picture.
Just my opinion, but I have built just about everything there is ...except maybe a skyscraper.

__________________

Just My
Made in the

inspectorD is offline  
 
Reply With Quote Quick reply to this message
Old 01-29-2009, 06:31 AM  
yesitsconcrete
Member
 
Join Date: May 2008
Posts: 88
Default

don't worry about the animals - they're smarter'n humans who often think rough surfaces wouldn't hurt them AGAIN

far's hanging ' stuff ' on the walls, if you want to suspend a tractor, you should think ahead,,, saddles & stuff rest on the floor but are shown on saddle trees - the weight's still on the floor, tho.


__________________
yesitsconcrete is offline  
 
Reply With Quote Quick reply to this message
Reply


Quick Reply
Message:
Options

Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


Similar Threads
Thread Thread Starter DIY Home Repair Forum Replies Last Post
Exterior spalling on cinder block foundation wall pkendron Bricks, Masonry and Concrete 1 06-18-2008 10:21 PM
Resurfacing Concrete/cinder block walls kayokayo Flooring 4 04-12-2008 12:16 AM
Install siding on cinder block OLDummy Bricks, Masonry and Concrete 29 02-05-2008 10:39 PM
Cracks in concrete block walls Mudball Bricks, Masonry and Concrete 2 07-17-2006 05:45 PM
Cinder block wall options J Hawkes Framing and Foundation 5 12-18-2005 10:46 PM

Newest Threads

LATEST SPONSOR DEALS